. 24/7 Space News .
The Case For Space Based Solar Power Development

solar energy on Earth and in space might be the first large scale space industry
by Arthur Smith
New York - Aug 11, 2003
Energy policy is in the news again, with debates in Congress, statements from presidential candidates, consternation over our dependence on the Middle East for oil, and a California recall election traceable in part to energy supply problems for that state. Use of energy, whether fuel for transportation, electrical energy running the internet, or the destructive energy released in weapons, is central to our economy and security.

It is with good reason that the technical term for energy use per unit time, "power", suggests control in the human world as well. Three actions taken now - working to reserve radio spectrum for power transmission, focusing on reductions in costs for space launch, and investing in space solar power system research - hold the promise of opening up vast new sources of power within the next 10-15 years.

Space is big - there is an awful lot of energy out there, and the crumbs we fight about here on Earth are laughably tiny in comparison. Zettawatts from the Sun pass just through the region between Earth and Moon - that's enough energy for each man, woman and child in the US to sustainably power an entire US economy all to themselves. Even our terrestrial energy choices, fossil or renewable, fission or wind, almost all derive from the energy profligacy of our Sun and other stars before it.

Gathering power in space and transmitting it to Earth should not be a mystery to us in this 21st century. Communications satellites already do it routinely. One significant obstacle to power applications, however, is regulatory: there is no spectrum allocated to power transmission, as there is for communications.

Since frequency of operation has a significant impact on transmitter design which may alter the design of the overall solar power system, the earlier we have a frequency allocation decision, the better. The Federal Communications Commission and the International Telecommunications Union should be prodded to start work on this issue now.

The potential for power from space has been recognized for over thirty years (1). Studies in the late 1970's by NASA and the Department of Energy produced a reference design for solar power satellites using then-current technology that showed technical feasibility, but also high cost. NASA returned to the subject with an exploratory study from 1999 to 2001.

A review by the National Research Council (2) found the program to have a credible plan which required significant funding increases. Rather than strengthening the program, however, all funding for the space solar power group ceased after September 2001, and essentially no R&D work on power from space is now being done in the US.

Worldwide over a trillion dollars a year goes to the energy industry, and utilities routinely construct multi-billion-dollar power plants. The energy industry has a bigger wallet than the entire US federal discretionary budget.

Money is not directly the problem here; profitability is. The two essential factors in the cost equation are the cost per delivered Watt of the solar power components, and the cost per delivered Watt of getting those components to their final destination in space.

Current costs put the capital investment needed for a space solar power system well above the $2/Watt of competitive terrestrial options such as fission plants and wind turbines. R&D work is needed to bring these costs to where the vast energy resources of space are within reach of a large utility project.

The cost of components is the first problem here. Current prices for solar electric power systems are about $2.50 per peak Watt, a price that has been declining about 7% per year for the last few decades. The day/night cycle, non-ideal sun angles, weathering, and cloud cover reduce power output enough to make the final cost per average Watt $10 or more. Terrestrial solar power is still too expensive for wholesale utility use, but it is now competitive for home owner installation in many areas.

In space you can get peak power almost all the time. The $2.50/Watt homeowner systems are not space-rated, but the space market is still small; with a larger market suitable photovoltaic elements could be produced at comparable cost. Transmitting power from space will have somewhat higher losses than transmitting from a terrestrial power plant.

Nevertheless, component costs are potentially much closer to wholesale utility requirements for space solar power than they are for terrestrial solar, and with continued improvement in prices, in another 10 to 15 years component costs should not be an obstacle to large-scale installation.

The other cost of concern is delivery to orbit. Typical communications satellite solar panels have a mass per kW of about 20 kg, so with current launch costs of $10,000/kg that comes to $200/Watt, or a hundred times too large to be competitive at the utility level. Bringing that number down requires both improvements in mass per kW, and cheaper access to space.

Mass per kW is sensitive to solar power system design (3). The NASA/DOE reference design came to 10 kg/kW; more recent studies of light-weight design options have suggested mass could be as low as 1 kg/kW (4).

Significantly more R&D effort to validate these designs and settle on a few cost-effective approaches would be extremely helpful here. The lower the mass requirement, the less we need to bring down launch costs to break the $2/Watt barrier.

Lower launch costs is a major goal of all space advocates. The X Prize contenders, Musk's Space-X, even the major aerospace "EELV" program all have the intention of significantly reducing launch costs.

Whether any rocket based system will succeed remains to be seen - perhaps we will have to wait for space elevators to see much reduction in cost to orbit. But there are some indicators that we could see a factor of 3-5 improvement, and perhaps more, over the next decade with a sufficiently large and competitive launch market.

Competition in the commercial launch market already has some providers such as Sea Launch offering $4000-$5000 per kg prices to low earth orbit. Use of solar electric propulsion allows higher orbits at only slightly higher cost. Given the multi-trillion-dollar potential market for space-based power, increased funding for launch systems development to accelerate these improvements would also be a worthy investment.

There is another way to reduce launch costs. In David Criswell's Lunar Solar Power proposal (5), instead of launching the final components from Earth, manufacturing facilities are sent from Earth to the Moon to build the solar power system components there. And to save even further on launch costs, the solar components stay on the Moon and transmit power directly from there.

The initial capital investment is higher than for an Earth-launched system primarily due to the much larger antennas needed to transmit power efficiently from Moon to Earth, but overall costs per delivered Watt should be much lower, and the costs for such an approach are less dependent on reducing launch costs from Earth.

Component and launch will not be the only costs - for example we need to learn how to cost-effectively put together very large (kilometer-scale) objects in space. Improved robotics and computational capabilities should make this much less expensive now than was true for the 1970's era designs, but it is another area where we need some experience to be confident in cost estimation. Further R&D in robotics may also be needed.

Looking at the major cost areas again, for the wholesale utility market space solar power is currently about a factor of 2 too expensive with regard to cost of materials and components, and at least a factor of 10 on the launch cost side. Both cost barriers have realistic chances of being overcome in the next decade.

The prospects for space-based solar power are at least as bright as for fusion power; these two options were identified as the only long-term sustainable energy sources in a report published in Science magazine last year (6). While space solar power has received essentially no government funding for two decades, fusion gets close to $1 billion/year.

The ITER fusion project scheduled for completion in 2014 will cost $5 billion for a research reactor that produces only thermal power - in contrast the 1995 "Fresh look" (7) study for space solar power found some systems with an estimated cost of $6 to $8 billion, producing 250 MW electric available for commercial sale, readily expandable to several GW and a profitable return on investment. With some further research those numbers can likely be improved upon, but the funding has been terminated rather than increased.

We already have an immense fusion reactor working for us in our solar system, ultimately responsible for almost all our energy choices. All we really need to do is make better use of it by tapping into it more directly.

Any rational energy policy for the United States must support the steps needed to make that happen: increased investment in reducing launch costs, reserving radio frequency spectrum for power transmission, and moving towards a billion dollars per year in a robust and diverse program of R&D on space solar power.

  1. Peter Glaser wrote about solar power satellites in 1968, William Brown proved the potential of wireless power transmission about that time, and solar power from space was an important part of physicist Gerard O'Neill's inspiring call to space in his 1977 book "The High Frontier". Grass roots organizations such as the Space Studies Institute and the National Space Society (NSS) continue to see space solar power as part of their vision of a space-faring future.

  2. "Laying the Foundation for Space Solar Power: An Assessment of NASA's Space Solar Power Investment Strategy" (2001) - National Research Council.

    NASA's "exploratory research and technology" program to map out a plan for implementation of space solar power received $15 million/year from 1999 to 2001 (NSS lobbying played a substantial role in obtaining that funding). Funding requirements for real technology development and flight demonstrations were quickly determined to be more in the range of several hundred million dollars per year. The NRC recommendations called for a more focused effort with the limited funding available, and improving collaboration with industry and other government agencies doing research in related areas. The NRC report pointed out the heavy dependence of practical space solar power on reductions in the cost of Earth-to-orbit transportation. NASA's Space Launch Initiative at the time was aiming for a 10-fold reduction in costs, and the report recommended close ties between the SSP and SLI programs to allow both to achieve their goals.

  3. Factors in mass per kW include the overall geometry, transmitter design, solar cell efficiency, use of mirrors or concentrators, radiation protection, and station-keeping propellant. A significant mass requirement comes from power handling within the satellite itself. If the cells can go directly to radio waves via a phased-array technique then this mass is not needed, but that will likely increase mass requirements in other areas.

  4. "Low Mass Solar Power Satellites Built From Terrestrial or Lunar Materials", S. D. Potter, SSI Update, Volume XX, Issue 1 (1994).

  5. "Solar power via the moon", David Criswell, The Industrial Physicist, Volume 8, Number 2, p. 12, (April/May 2002);

  6. "Advanced Technology Paths to Global Climate Stability: Energy for a Greenhouse Planet", M. Hoffert et al., Science Vol. 298, p. 981 (2002).

  7. "A Fresh Look at Space Solar Power: New Architectures, Concepts and Technologies", John C. Mankins, 38th International Astronautical Federation conference (1997); available online: Copyright 2003 Arthur P. Smith.

Arthur Smith is the President, Long Island Space Society and can be contacted via apsmith @ aps.org

Related Links
Search SpaceDaily
Subscribe To SpaceDaily Express

Next-Generation Solar Cells Could Put Power Stations In Space
Rochester - Jan 08, 2003
Someday, large-scale solar power stations in space could beam electricity to the surface of the moon, the earth and other planets, decreasing our dependence on a dwindling fossil-fuel supply.

Thanks for being here;
We need your help. The SpaceDaily news network continues to grow but revenues have never been harder to maintain.

With the rise of Ad Blockers, and Facebook - our traditional revenue sources via quality network advertising continues to decline. And unlike so many other news sites, we don't have a paywall - with those annoying usernames and passwords.

Our news coverage takes time and effort to publish 365 days a year.

If you find our news sites informative and useful then please consider becoming a regular supporter or for now make a one off contribution.
SpaceDaily Contributor
$5 Billed Once

credit card or paypal
SpaceDaily Monthly Supporter
$5 Billed Monthly

paypal only

The content herein, unless otherwise known to be public domain, are Copyright 1995-2016 - Space Media Network. All websites are published in Australia and are solely subject to Australian law and governed by Fair Use principals for news reporting and research purposes. AFP, UPI and IANS news wire stories are copyright Agence France-Presse, United Press International and Indo-Asia News Service. ESA news reports are copyright European Space Agency. All NASA sourced material is public domain. Additional copyrights may apply in whole or part to other bona fide parties. Advertising does not imply endorsement, agreement or approval of any opinions, statements or information provided by Space Media Network on any Web page published or hosted by Space Media Network. Privacy Statement All images and articles appearing on Space Media Network have been edited or digitally altered in some way. Any requests to remove copyright material will be acted upon in a timely and appropriate manner. Any attempt to extort money from Space Media Network will be ignored and reported to Australian Law Enforcement Agencies as a potential case of financial fraud involving the use of a telephonic carriage device or postal service.